Product ID:D-6449-RS AEROSOL LIME GREEN RANDACRYL
MSDS Date:11/20/1992
FSC:NIIN:Submitter:F BT
Status Code:A
MSDS Number: CKXQS

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700

Info Phone: 201-438-3700

Preparer: JHR

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE

CAS: 108-65-6

RTECS: AI8925000

ACGIH TLV: 100 PPM

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETONE

CAS: 67-64-1

RTECS: AL3150000

ACGIH TLV: 750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPANE(49.7 MOL%)/ ISOBUTANE(50.3 MOL%)

CAS: 68476-86-8

ACGIH TLV: NO INFO

ACRYLIC RESIN SOLUTION

ACGIH TLV: 100 PPM

SUCROSE ACETATE ISOBUTYRATE

ACGIH TLV: 1000 PPM

LEAD CHROMATE YELLOW

CAS: 1344-37-2

ACGIH TLV: 0.5 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Explanation of Carcinogenicity:LEAD CHROMATE YELLOW
Effects of Overexposure:HARMFUL IF ABSORBED THROUGH SKIN. CHRONIC
HEALTH EFFECTS ARE POSSIBLE FROM LONG TERM EXPOSURE TO THIS
MATERIAL, INCLUDING DRYING, CRACKING AND IRRITATION OF THIS SKIN.
REACTS WITH SKIN PROTEIN AND M OISTURE AND CAN CAUSE RASH, SCALING
OR BLISTERING. HIGH CONCENTRATIONS MAY CAUSE HEADACHES AND
DIZZINESS, ARE ANESTHETIC, AND MAY HAVE OTHER CENTRAL NERVOUS
SYSTEM EFFECTS, INCLUDING DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO THIS
PRODUCT.

First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. SKIN:
FLUSH WITH WATER. EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF
WATER. INGESTION: DO NOT INDUCE VOMITING. KEEP PEROSON WARM AND
QUIET. IN ALL CASES, SEEK IMMEDIATE MEDICAL ATTENTION!

Flash Point Method:SCC
Flash Point:=-72.6C, -99.F
Lower Limits:1.0
Upper Limits:12.8
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:UTILIZED SELF-CONTAINED BREATHING APPARATUS TO
AVOID INHALATION OF POTENTIALLY TOXIC FUMES. VAPORS>AIR MAY TRAVEL
TO DISTANT IGNITION SOURCES & FLASHBACK.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT,SPARKS,AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUI LD-UP AND POSSIBLE AUTOIGNITION
OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT. REMOVE ALL NON-ESSENTIAL
PERSONNEL FROM FIRE

Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. AVOID SPARKS, FLAMES, AND ANYTHING WHICH COULD CAUSE
FIRE. ELIMINATE SOURCE OF SPILL IF YOU CAN DO SO WITHOUT RISK BY
CLOSING VALVE, PLUGGIN G HOLE, ETC.. APPLY ABSORBENT INERT MATERIAL
(SAND, DUST, VERMICULITE) TO SPILL. CLEAN SPILL WITH BRISTLE
BROOMS, NON-SPARKING TOOLS, CLEAN DRY RAGS. PROTECTIVE CLOTHING
SHOULD BE WORN.

Handling and Storage Precautions:DUE TO VARIATIONS IN RAW MATERIAL
BATCHES THERE MAY BE TRACE ELEMENTS OF SUBSTANCES NOT LISTED WHICH
WOULD NOT REQUIRE CHANGES TO THIS SHEET.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR TYPES SUITABLE
FOR MATERIALS RECOMMENDED. APPROVED CHEMICAL/MECHANICAL FILTERS
RECOMMENDED WHEN VENTILATION IS RESTRICTED. PRECAUTIONS MUST BE
TAKEN SO THAT PERSONS DO N OT BREATHE THE VAPORS OR HAVE CONTACT
WITH EYES OR SKIN. PROTECT AGAINST EXPOSURE TO BOTH VAPOR AND SPRAY
MIST.
Ventilation:SUFFICIENT VENTILATION, IN VOLUME AND PATTERN, SHOULD BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW EXPOSURE LIMITS.
Protective Gloves:POLYETHYLENE GLOVES.
Eye Protection:CHEMICAL GOGGLES WITH SIDE SHIELDS OR FACE SHIELD
RECOMMENDED.
Other Protective Equipment:USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. USE NORMAL HYGIENE PRACTICES DURING AND AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
WT/GAL = 7 HMIS RATING: HEALTH=1, FLAMMABILITY=4, REACTIVITY=0.

Boiling Pt:B.P. Text:105-302 F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN GREEN LIQUID WITH A TYPICAL SOLVENT ODOR.
Percent Volatiles by Volume:88.2

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:STORE THIS PRODUCT INDOORS TO PROTECT FROM
FREEZING.
Hazardous Decomposition Products:THERMAL DECOMPOSITION RELEASES
ALDEHYDES.

Waste Disposal Methods:CONTAINS LEAD-DISPOSE OF IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE, CUT OR
WELD EMPTY CONTAINERS. WHEN DISCARDED THIS MATERIAL IS A HAZARDOUS
WASTE. TRANSFER LIQUID TO CONTAINERS FOR RECOVERY OR DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:THIS PRODUCT CONTAINS ONE OR MORE MATERIALS
SUBJECT TO THE REPORTING REQUIREMENTS.